Solar Water Heater Maintenance Checklist

Install pump onto the water heater discharge using pipe fitting.

Solar water heater maintenance checklist.

Annual water heater maintenance checklist drain and flush tank drain and flush tank very important for gas water heaters. The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Solar water heating system maintenance and repair periodic inspection list. Allow a few gallons worth of water to drain.

With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater. Open a hot water. Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for.

Be sure to check the water draining out and make sure it is clear. Satisfactory not satisfactory 2 quantity of hot water supply. Solar hot water heaters are no different except that because they have more components there is more that can go wrong. Drain the water from the hot water pipe.

Check to make sure the water to the hot water heater has been completely shut off. Drain 2 3 gallons of water. When calling for assistance please have the following. Use a solution of dish soap and warm.

Turn off cold water supply and open drain valve. If that is too. Disconnect the hot water heater at the hot water discharge. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector.

If it is then you are set to refill the tank. Here are some suggested inspections of solar system components. Close drain valve and open cold water supply valve. Regularly scheduled maintenance should include.

Satisfactory not satisfactory 3 constant temperature e g. Open t p relief valve to relieve pressure. Also read your owner s manual. Two major factors affecting the performance of properly sited and installed solar.

Let the water run until it stops flowing. Preventing scaling and corrosion. If water is milky drain entire tank. Whether the tank is gas or electric turn off its heating source the night before.

Turn off the heat.